Toyota 4 Runner/Hilux/Surf

1987-1998 of release

Repair and operation of the car

Toyota 4ranner
+ 1. Maintenance instruction
+ 2. Maintenance
+ 3. Engines
- 4. Systems of heating, ventilation
   4.1. Specifications
   4.2. Antifreeze
   4.3. Thermostat
   4.4. Krylchatka of the fan and hydraulic clutch
   4.5. Radiator and tank
   4.6. Oil cooler
   + 4.7. Pump
   4.8. Liquid temperature sensor
   4.9. Electric motor and chain of the fan of a heater
   4.10. Heater radiator
   4.11. Control panel of the conditioning block
   - 4.12. Air conditioning system
      4.12.1. Check of gas station of coolant
      4.12.2. Heater
   4.13. Compressor
+ 5. Fuel and exhaust systems
+ 6. Transmissions
+ 7. Transmission elements
+ 8. Brake system
+ 9. Suspension bracket and steering
+ 10. Body
+ 11. Electric equipment
+ 12. Electrical circuitries

4.12.2. Heater

Check

PERFORMANCE ORDER

1. If heating of air in a heater is absent, then the following can be the reasons:

  – the thermostat is not closed therefore liquid is warmed insufficiently and badly warms up a heater radiator – replace the thermostat (see subsection 4.3);
  – the heater hose is littered that interferes with a liquid stream through a radiator – disconnect hoses and wash out a radiator a water stream from a hose;
  – if water does not pass through a heater radiator, then the radiator is littered and is subject to replacement.

2. If from exhaust outlets of air ducts air does not arrive, then arrive as follows:

– turn the ignition key in position of ON and turn on the fan (noise of the working electric motor has to be listened).
– if the rumble of the electric motor is not listened or if check shows that the switch and the block of resistors are serviceable, then malfunction of the electric motor can be the cause.

3. If the rug is moistened, or through air vents vapors of cooling liquid get, then in a radiator of a heater there is a leak. Replace a radiator.

4. Check purity of a drain hose of a moisture separator.